Low-power uncooled 120x160 a-Si-based micro infrared camera for unattended ground sensor applications

Thomas R. Schimert; John F. Brady III; Steven J. Ropson; Roland W. Gooch; Bobbi Ritchey; P. McCardel; A. J. Syllaios; John H. Tregilgas; K. Rachels; M. Weinstein; John Wynn

doi:10.1117/12.392561

21 July 2000 Low-power uncooled 120x160 a-Si-based micro infrared camera for unattended ground sensor applications

Thomas R. Schimert, John F. Brady III, Steven J. Ropson, Roland W. Gooch, Bobbi Ritchey, P. McCardel, A. J. Syllaios, John H. Tregilgas, K. Rachels, M. Weinstein, John Wynn

Author Affiliations +

Proceedings Volume 4040, Unattended Ground Sensor Technologies and Applications II; (2000) https://doi.org/10.1117/12.392561
Event: AeroSense 2000, 2000, Orlando, FL, United States

Abstract

Low power and low cost are primary requirements for an imaging infrared camera used in unattended ground sensor arrays. In this paper, a 120 X 160 amorphous silicon (a- Si) microbolometer-based uncooled infrared camera technology offering a low cost, low power solution to infrared surveillance for UGS applications is presented. A 120 X 160 micron infrared camera (MIRC) has been demonstrated which exhibits an f/1 noise equivalent temperature difference sensitivity approximately 63 mK. This sensitivity has been achieved without the use of a thermoelectric cooler for array temperature stabilization thereby significantly reducing the power requirements. Chopperless camera operation at a 20 Hz frame rate with power consumption of 380 mW has also been demonstrated. The 120 X 160 MIRC operates under digital signal processor (DSP) control. To reduce cost, this DSP-controlled architecture employs commercial off-the-shelf DSP, A/D, memory and voltage regulator chips. The detector chip, employing an integrating amplifier per unit cell ROIC design, is the single custom chip used. The camera also employs low cost f/1 optics, as well as low cost wafer-level vacuum packaging. In this paper, a-Si microbolometer technology for the MIRC will be presented. Also, the key features and performance parameters of the MIRC are presented.

Citation Download Citation

Thomas R. Schimert, John F. Brady III, Steven J. Ropson, Roland W. Gooch, Bobbi Ritchey, P. McCardel, A. J. Syllaios, John H. Tregilgas, K. Rachels, M. Weinstein, and John Wynn "Low-power uncooled 120x160 a-Si-based micro infrared camera for unattended ground sensor applications", Proc. SPIE 4040, Unattended Ground Sensor Technologies and Applications II, (21 July 2000); https://doi.org/10.1117/12.392561

ACCESS THE FULL ARTICLE

INSTITUTIONAL
Select your institution to access the SPIE Digital Library.

SELECT YOUR INSTITUTION

PERSONAL
Sign in with your SPIE account to access your personal subscriptions or to use specific features such as save to my library, sign up for alerts, save searches, etc.

PERSONAL SIGN IN

No SPIE Account? Create one

;

PURCHASE THIS CONTENT

SUBSCRIBE TO DIGITAL LIBRARY

50 downloads per 1-year subscription

Members: $195

Non-members: $335 ADD TO CART

25 downloads per 1 - year subscription

Members: $145

Non-members: $250 ADD TO CART

PURCHASE SINGLE ARTICLE